What to Do When the Fuel Tank Cap of Volkswagen Magotan Won't Open?
3 Answers
Solutions for when the fuel tank cap of a Volkswagen Magotan won't open are: 1. For mechanical issues, turn off and lock the car, then unlock and try again; 2. If the spring inside the fuel tank cap is stuck, pry open the cap and apply lubricant to the spring. Taking the Volkswagen Magotan 2020 model as an example, it is a 4-door, 5-seater sedan with body dimensions of length 4865mm, width 1832mm, height 1471mm, a wheelbase of 2871mm, and a fuel tank capacity of 66 liters. The Volkswagen Magotan 2020 is equipped with a 2.0T turbocharged engine, delivering a maximum horsepower of 220 PS and a maximum power of 162 kW.
Last time my Magotan’s fuel filler cap wouldn’t open either, and it drove me crazy. Later, I discovered an emergency release hidden in the trunk—just lift the right-side interior trim panel to find a small pull ring, and a quick tug does the trick. If that fails, try repeatedly pressing the car key’s unlock button while pressing the edge of the fuel cap with your hand; the vibration might loosen the stuck locking mechanism. During regular car washes, pay special attention to cleaning dirt and debris around the fuel cap area to prevent the pivot from jamming. If this happens frequently, it’s likely either a faulty motor in the locking mechanism or a rusted cable. After an emergency release, it’s best to visit a repair shop promptly for a full inspection—replacing a small part usually solves the issue. Also, when refueling, avoid turning off the engine immediately; wait until the fuel cap pops open to protect the motor.
There are basically four reasons why the fuel tank cap of the Magotan won't open: lock block failure, cable detachment, motor damage, or control circuit short circuit. If you encounter this situation, don't force it open. First, check if the central locking system of the vehicle is unlocked. If the emergency pull hook in the trunk also fails, you can try a power reset—disconnect the negative terminal of the battery for a few minutes and then reconnect it. I've seen some cases where the fuel tank cap spindle is stuck due to lack of lubrication, and a spray of WD-40 solves the problem. During repairs, pay special attention to whether the wiring harness connector on the right side of the trunk is loose, as this is a common issue with Volkswagen vehicles. DIY disassembly can easily break plastic clips, so it's best to have a professional handle it. Daily care should include avoiding impacts on the fuel tank cap, as deformation of the latch makes it difficult to reset.
