How to Deal with Brake Noise in Zotye T600?
3 Answers
Zotye T600 brake noise treatment methods: 1. Check the brake discs and brake pads for grooves and debris, remove the brake pads for grinding; 2. Observe whether the sound is from the warning plate. When the brake pads wear to the limit, the warning plate rubs against the brake disc, producing a sharp metal friction sound. To avoid damage to the brake discs and brake failure, the brake pads must be replaced in time. The Zotye T600 is a mid-size SUV under the Zotye brand, with dimensions of 4631mm, 1893mm, and 1694mm, and a wheelbase of 2807mm. The Zotye T600 is equipped with a 1.5L turbocharged engine, paired with a 5-speed manual transmission.
My Zotye T600 used to have annoying brake squealing too, but I figured out a few tricks that worked well. First, don't rush to disassemble parts—recall if you've recently changed brake pads or driven on muddy roads. New brake pads need at least 200-300 kilometers to quiet down. If they're contaminated with mud or sand, use a water spray to clean the inner side of the wheel hub. If the brakes squeal lightly when pressed gently in city driving but work normally under hard braking, it's likely due to hard spots on the edges of the brake pads or the backing plate rubbing against the rotor. Just sand down the edges with sandpaper. Oh, and don’t forget to check if the brake rotors have grooves—if they feel uneven, they need resurfacing. If there’s metallic grinding noise along with pedal vibration, check for warped brake rotors immediately—this should never be delayed.
When encountering brake noise, first distinguish between cold and hot vehicle conditions. A single "squeak" when pressing the brake pedal in the morning is mostly normal, but persistent noise while driving requires attention. Turn the steering wheel fully to inspect the brake disc surface—visible metal streaks indicate worn-out brake pads that need immediate replacement, along with checking for deformed retaining springs. If brakes whistle like blowing a whistle in rainy weather, it's likely due to stones stuck in drainage grooves, which can be pried out with a screwdriver tip. Pay special attention to frosted brake discs in winter, as sudden braking may produce a cloth-tearing sound; warming up the car for ten minutes before driving resolves this. For brake pad replacement, it's recommended to replace the entire set, as replacing individual pads may cause incompatibility with old discs.
